Exhibition

Home > Exhibition > Content
Permanent Magnet Motor Magnetic Tile
Jul 29, 2017

Speaking of permanent magnet motor magnetic tile magnetizing method, it is actually including the permanent magnet motor magnetic tile alone after the magnetization, and then into the chassis which, the final assembly of the whole; the second way is the magnetic tile into To the case (stick good) after the magnetization, the final assembly of the whole; the third way is the magnetic tile into the chassis (stick good), followed by a direct assembly of finished products, and finally in the overall magnetization.

For the above three ways, it is the impact of permanent magnet motor magnetic tile motor is not the same. First of all, for the first kind of magnetizing method, it is actually seen when the application is more than the second, three kinds of magnetic surface remanence of about 10% lower, that is, under normal circumstances, we actually That is, will be directly on the use of the second magnetic way, which is more reasonable way to magnetization.
Motor magnetic tile.jpg

But the first permanent magnet motor magnetic tile on the magnetization method is actually very convenient, and some factories will use the solenoid tunnel type magnetization, production efficiency will be greatly improved; the use of the second Way to magnetize, and some plants will be based on the actual situation using the external red, and some will use the red, magnetic tile or magnetic ring need to stick a good first drying, so that the production will be a lot easier.
Motor magnetic tile.jpg

The third kind of permanent magnet motor magnetic tile magnetic way, in fact, there are more small motor (mostly three slots) will use this way, when it is installed in the rotor, because there is no good assembly of magnetic force, but also It is not particularly convenient for us to check the magnet is not good.

The first permanent magnet motor magnetic tile magnetization method is actually open circuit magnetization, because the magnetic field when there is no magnetic field outside the magnetic field, it will not constitute a closed loop. But the actual permanent magnetic motor magnetic magnet magnetization, we should pay attention not to charge too saturated, because the magnetic tile magnetic flux density will have a great impact, it is also the case, it is also It is more than the closed-end magnetism to be lower.


If you are interested in our products, please contact us!
WUXI JINWEI PERMANENT MAGNET CO., LTD.
Contact: ZhangWenya
Phone: +86-510-83781871
Fax: +86-510-83784760
Mobile: +86-13506196722
Email: jwmagnet@188.com
Website: http://www.jinweimagnetic.com







Copyright © Wuxi Jinwei Permanent Magnet Co.,Ltd All rights reserved.Tel: +86-510-83781871